Businessweek: How Airbus Is Debugging the A350

Businessweek A350 wingtip smallA few times a month, Airbus Flight Test Engineer Patrick du Ché stands up from his desk, takes off his jacket and tie, walks to the coat rack in the corner of his office, and slips into a set of fire-resistant underwear, a bright-orange flight suit, and sturdy black boots. Then he walks down two flights of stairs and out onto the tarmac of Toulouse-Blagnac Airport in southern France. There, rising above a fleet of newly painted A320 short-haul jets, is an Airbus A350-XWB long-range widebody airliner—the very first of its kind. Sleek and nearly all white except for the lettering along its flank and the swirling blue-on-blue Airbus logo on the tail, it carries the official designation MSN001. Last May, in a modest employees-only ceremony, the final assembly line workers formally handed the plane over to the Flight Test Department. Or, as du Ché sees it, “They handed it to me.”

As a flight engineer and head of the department, du Ché gets first pick of the test flights. Although he describes himself as risk-averse, he tends to choose those he calls the most “interesting,” which means at the edge of the plane’s capabilities, where if something goes wrong, it could destroy the plane. Since June, du Ché and his colleagues have flown at the A350’s maximum design speed; conducted aerodynamic stalls; and taken off so slowly that the tail dragged on the ground.

Each test flight is operated by a crew of two pilots and three flight engineers, who monitor the stream of data flowing from a multitude of sensors into a bank of computers installed in the middle of the cabin. Du Ché’s station is behind the co-pilot’s on the right side of the cockpit. On the seat is a parachute. If things should go terribly awry and the crew needs to evacuate, a bright-orange railing leads them from the cockpit door to a hatch in the floor above the forward baggage compartment. By pulling a lever, the crew can trigger a set of explosive charges that will blow a hole in the right side of the fuselage. They can then leap down a slide, through the hole, and into the air. That’s the idea, anyway. Says test pilot Frank Chapman: “If the plane is tumbling out of control, would you really be able to get out?” He shrugs.

Read the rest of the article, from the February 13, 2014 issue of Bloomberg Businessweek, here.

One thought on “Businessweek: How Airbus Is Debugging the A350”

  1. They should require a Boeing 727 tail cone exit, like D. B. Cooper. And the seat back should be a parachute for 300 pound person. The seat cushion should be a parachute for a 150 pound person.

Leave a Reply

Your email address will not be published. Required fields are marked *

This site uses Akismet to reduce spam. Learn how your comment data is processed.